Helmet Noise by Helmet Stuff.com

Noise levels under motorcycle helmets

We have measured noise levels at the ears of police motorcyclists in a wind tunnel and on the road, with several different helmets and motorcycles. Noise levels in the wind tunnel were similar to those on the road. 

Wind Tunnel tests for Motorcycle Helmet Noise
The measurements in the wind tunnel showed the main source of noise to be the turbulence at the edge of the windscreen's wake acting on the helmet. The rank ordering of helmets by the noise level depended upon the motorcycle and in particular the windscreen height - a helmet which is relatively quiet on one motorcycle can be relatively noisy on another and vice-versa. Low windscreens direct the turbulence to the base of the helmet, and modifications to improve the helmet seal around the neck can reduce noise levels on motorcycles with low windscreens. High windscreens direct the turbulence to the helmet visor and forehead, and modifications to improve the sealing of the visor to the helmet shell are then effective. Such simple modifications to helmets can reduce noise levels by between 5 dB and 8 dB at the ear.

Wind tunnel tests with a flying helmet containing active noise reduction earmuffs demonstrated that noise levels as low as 70 dB(A) at 80 km/h and 80 dB(A) at 115 km/h were achievable at the ear. Similar systems within a motorcyclist's helmet suggest that this potential will not be realised unless the earmuffs are well isolated from the helmet shell and liner. Another method of achieving similarly low levels is to wear good earplugs. Many police forces in the UK are now providing these for their motorcyclists.

If you ride a motorcycle and your hearing sounds muffled afterwards, or if your ears ring, then you are suffering temporary hearing damage, which, if repeated regularly, may become permanent hearing damage. We recommend you consider wearing earplugs under the helmet.  Because the earplugs reduce the noise, you may seem to be travelling more slowly, so take extra care to check your speed until you get used to the earplugs.

This project was carried out for the Home Office by ISVR Consulting, the Department of Aeronautics and Astronautics, the Wolfson Unit for Marine Technology and Industrial Dynamics, and Hampshire Constabulary.

We have also measured the noise exposures of motorcycle patrols for one of the motorist breakdown rescue services.  The measurements were carried out during the motorcyclists' normal duties to determine whether their full-day noise exposures were below the limits of the UK Noise at Work Regulations.

References in the open literature:

M.C. Lower, D.W. Hurst, A.R. Claughton and A. Thomas, 1994; Sources and levels of noise under motorcyclists' helmets. Proceedings of the Institute of Acoustics, 16, pt 2, 319-326. ISBN 1 873082 59 2.

M.C. Lower, D.W. Hurst and A. Thomas, 1996; Noise levels and noise reduction under motorcycle helmets. Proceedings of Internoise '96, Book 2, 979 - 982.